零价铁复合有机膨润土处理染料废水的研究

针对目前印染废水处理现状及膨润土在水处理中回收困难等问题，提出将零价铁复合到有机膨润土中制成零价铁复合有机膨润土(ZVI-OB)，以达到高效吸附并降解污染物的目的。以染料废水(Orange II) 作为研究对象，考察了废水中染料的初始浓度、pH以及吸附时间对ZVI-OB去除染料效率的影响，并研究了吸附后降解过程中时间和pH对污染物降解的影响以及降解前后膨润土层结构的变化。研究结果表明，ZVI-OB相对于CTMAB改性的有机膨润土而言，其吸附量有所降低，但ZVI-OB在吸附污染物之后能有效降解有机物。ZVI-OB在饱和吸附Orange II后经催化氧化，总有机碳含量降低为原来的19%，可以重复利用。     

A method for the determination of rhodamine b and brilliant sulfaflavine on cotton string collectors and in a spray tank solution mixture

Abstract

A fluorescent method for the determination of rhodamine B (RhB) and brilliant sulfaflavine (BSF) dual tracers on cotton string collectors and in spray tank solutions was developed for the evaluation of the effects of adjuvants on the atmospheric drift of agricultural sprays. Both tracers on collectors were extracted with deionized water simultaneously and measured directly with a Fluorescent Specrometer by switching the maximum excitation and emission wavelengths. The linear ranges of the RhB and BSF standard curves were 0–50 and 0–10 ppb respectively. Recoveries of tracers on cotton strings ranged from 92.9% ± 1.1% to 95.1% ± 1.0% for RhB and 91.9% ± 2.8% to 103% ± 0.6% for BSF when spiked levels ranged from 0.25 to 2.5 μg per collector. The detection limit of the instrument was approximately 0.1 ppb for both tracers. The detection limits of the analytical method were approximately 0.1 ppb for RhB and 0.3 ppb for BSF when the background levels of cotton strings were subtracted. The presence of one tracer in the solution did not significantly interfere with the detection of the other tracer in the same solution. The presence of adjuvants added to the spray tank solutions did not interfere with the detection of both tracers when the adjuvants were applied at the manufacturer's maximum recommendation rates.     

雾化介质阻挡放电联合电晕放电对染料溶液脱色研究

实验将介质阻挡放电与电晕放电组合在一个反应器内,以靛蓝二磺酸钠溶液为实验废水,将高压电极上通入50Hz交流高压电,在常压空气中形成介质阻挡放电-电晕放电系统,放电产生的低温等离子体及其活性基团作用于染料分子。考察了电源电压、电极间距、处理时间对染料溶液脱色率和能量效率水平的影响,确定反应器工作状态为介质阻挡放电系统电极间距30mm、电晕放电系统电极间距25mm、电源电压20kV。     

壳聚糖/纳米CdS复合颗粒可见光光催化降解猩红B动力学研究

采用仿生矿化法制备了壳聚糖/纳米CdS复合颗粒光催化剂,并用于可见光光催化降解猩红B染料模拟废水,研究了猩红B初始浓度、pH、催化剂投加量和催化剂重复使用次数等因素对猩红B光催化降解的影响.X射线衍射(XRD)分析表明,壳聚糖能有效负载CdS纳米微晶.采用Langmuir-Hinshelwood模型描述壳聚糖/纳米CdS复合颗粒可见光光催化降解猩红B反应动力学行为,在猩红B初始质量浓度较低(≤20 mg/L)时,光催化降解过程符合假一级动力学方程.降低猩红B初始浓度和溶液pH都可显著增大光催化降解速率常数;催化剂投加量小于0.7 g/L时,光催化降解速率随其增加而增大,但催化剂投加量过大会使光催化降解速率减小;催化剂重复使用第5次时,猩红B光催化降解速率常数仍为第1次使用时的63.4%.     

Loofa egyptiaca as a novel adsorbent for removal of direct blue dye from aqueous solution

In this paper, Loofa egyptiaca (LE), an agricultural plant cultivated in Egypt, was used to prepare low-cost activated carbon (LE_C1 and LE_C2) adsorbents. The adsorbents (LE, LE_C1 and LE_C2) were evaluated for their ability to remove direct blue 106 dye from aqueous solutions. Batch mode experiments were conducted using various parameters such as pH, contact time, dye concentration and adsorbent concentration. The surface chemistry of LE, LE_C1 and LE_C2 was analyzed by scanning electron microscopy (SEM). The experimental data were examined using Langmuir, Freundlich, Temkin and Harkins–Jura isotherms. The results showed that the adsorption of direct blue 106 was maximal at the lowest value of pH (pH = 2). Removal efficiency was increased with an increase in dye concentration and a decrease in amount of adsorbent. Maximum adsorption capacity was found to be 57.14, 63.3 and 73.53 mg/g for LE, LE_C1 and LE_C2 respectively. Kinetics were also investigated using pseudo-first-order, pseudo-second-order and intra-particle diffusion models. The experimental data fitted very well with the pseudo-first-order and pseudo-second-order kinetic models. The results indicate that LE, LE_C1 and LE_C2 could be employed as adsorbents for the removal of direct blue dye from aqueous solutions.     

Fenton试剂氧化法处理染料结晶废母液

采用Fenton试剂氧化法处理分散橙、分散紫和分散蓝3种染料结晶废母液。研究了H₂O₂加入量、n（H₂O₂）#x02236;n（Fe²⁺）和废母液pH对COD去除率或TOC去除率的影响。对TOC去除反应分段进行了动力学方程拟合，并探讨了反应机理。实验得到的分散橙、分散紫和分散蓝的废母液处理工艺条件：H₂O₂加入量分别为264.4，352.9，441.2mmol/L；n（H₂O₂）#x02236;n（Fe²⁺）分别为20，10，20；废母液pH=3。3种废母液在0~20min和20~120min两个阶段的反应与二级动力学拟合方程的相关性最好。3种废母液经Fenton试剂氧化处理后，部分有机物降解为小分子有机酸，部分有机物完全矿化。     

ClO2氧化法预处理联苯胺类染料中间体废水

采用ClO₂氧化法预处理联苯胺类染料中间体生产废水，探讨了影响COD和联苯胺去除率的主要因素，并采用GC/MS技术对ClO₂氧化前后废水中的有机组分进行了分析。实验确定了较佳的工艺参数：ClO₂加入量为45~55 mg/L，ClO₂与联苯胺的化学计量比控制在（3.0~3.5）∶1，反应时间为 30~35 min。在此条件下，ClO₂氧化后出水中联苯胺去除率达到80%以上，联苯胺类污染物含量得到有效降低，废水BOD₅/COD由原水的0.18提高到0.40。该方法能提高废水的可生化性，是一种较好的生化预处理技术。     

活性炭多维电极法处理活性染料模拟废水的机理研究

以活性嫩黄K-4G染料模拟废水为处理对象,探讨了多维电极系统处理活性染料废水时色度、COD降解的效果和机理。结果表明,活性炭多维电极法对染料废水的处理效果优于单纯电解法和单纯活性炭吸附法;氧化和还原作用对染料的色度和COD去除效果相差不大;增大处理系统中溶液的循环流量可显著改善活性炭多维电极系统对COD和色度的去除效果。     

直接染料在兼氧条件下的生物降解性能研究

实验分析了6大类14种直接染料在兼氧条件下的降解性能和脱色效果。在未加葡萄糖的实验中,采用不同温度（20℃与35℃）和不同停留时间来测定染料的降解性能。结果表明,35℃下的最佳停留时间为48h,此时的COD。的去除率及脱色均有较好的效果,而在72h的停留时间下,降解效果无明显提升。20℃下最佳停留时间则为72h,此时的COD。去除率及脱色效果与35℃下的结果很接近。在添加葡萄糖的实验中得到结果证实了葡萄糖作为在共代谢作用中的碳源对促进染料的降解起到非常积极的作用。     

电化学催化氧化法降解水中甲基橙的研究

采用电沉积-热解氧化法制备了含有中间层SnO2+Sb2O3的钛基体二氧化铅电极(Ti/SnO2+Sb2O3/PbO2),以甲基橙水溶液为模拟废水,研究了所制备的电极对其所具有的电催化氧化脱色性能。考察了电极制备条件对电极催化性能的影响,同时对甲基橙脱色降解实验条件进行了优化。用该电极对含60mg/L甲基橙的模拟废水处理2h,脱色率可达到82.21%,COD去除率为76.75%。